- -
Help with fuel gauge
(
http://www.clubcobra.com/forums/contemporary-classic-forums/146304-help-fuel-gauge.html)
| Pmccooey |
10-18-2022 11:40 AM |
Help with fuel gauge
To anyone that has the aluminum trunk and aluminum extra large tank. My fuel gauge is pegged at full when I turn the car on. I went looking for the sending unit on the tank and am having problems. Underneath is just the bottom of the fuel tank with a drain plug. On top in the trunk is all aluminum and appears to be riveted on so no access to the top from there. Do I need to drop the tank to gain access? That is if the tank even drops that easy. It’s a large aluminum tank shaped like a U so the sides go up inside the quarter panels.
Thanks,
Pat
|
| mvanhorn8893 |
10-18-2022 01:40 PM |
I would be interested to see the underside of your car. I don't have the big tank or aluminum inner panels but my sending unit is in the front top of the tank and you can reach it for connecting the wires by hand. You would likely need to drop the tank to remove the sender. I'm curious if they removed the fiberglass floor of the trunk or just built the aluminum panels on top of that.
Thanks, Mike
|
| Pmccooey |
10-18-2022 02:17 PM |
Quote:
Originally Posted by mvanhorn8893
(Post 1511315)
I would be interested to see the underside of your car. I don't have the big tank or aluminum inner panels but my sending unit is in the front top of the tank and you can reach it for connecting the wires by hand. You would likely need to drop the tank to remove the sender. I'm curious if they removed the fiberglass floor of the trunk or just built the aluminum panels on top of that.
Thanks, Mike
|
I’ll grab some pictures tomorrow to show you. I have seen other Contemporary’s with the option for the trunk. Not sure if the aluminum tank was an option or custom. |
| Pmccooey |
10-18-2022 02:51 PM |
3 Attachment(s)
Here are some pictures
|
| Morris |
10-18-2022 06:18 PM |
|
| Pmccooey |
10-19-2022 05:34 AM |
Quote:
Originally Posted by Morris
(Post 1511341)
|
Thanks! Is that a picture of yours? I’ll get it up on the lift and see if I can hopefully find the wire connection first so I can test that before dropping the tank. |
| Morris |
10-19-2022 09:54 AM |
Quote:
Originally Posted by Pmccooey
(Post 1511351)
Thanks! Is that a picture of yours? I’ll get it up on the lift and see if I can hopefully find the wire connection first so I can test that before dropping the tank.
|
It is .....and you need a vent on both sides of the tank as well as a return line from the engine. |
| 1985 CCX |
10-24-2022 06:06 AM |
The CCX tank is most likely flat so the vents on both side not like it would be for a 40 gallon tank.
I would pop off wheels and check for the sender under a wheel well or worse case drill out rviets as its easy to do.
My HTM car sender is in wheel well access point.
|
| RockBit |
10-24-2022 09:24 AM |
When I was troubleshooting my fuel gauge, I found that when the gauge sensor wire was grounded, the fuel gauge was pegged to full. You might want to check continuity between your sensor wire and ground.
Here is the thread from my ordeal:
http://www.clubcobra.com/forums/era-...gas-gauge.html |
| 1985 CCX |
10-24-2022 10:57 AM |
Also, check to see if it is full. :rolleyes:
|
| Pmccooey |
10-24-2022 03:35 PM |
Thanks for all the help. I had a little time between rain storms to dig into it. Found the sending unit int the middle of the tank towards the front. Ground from the sending unit tested good. Traced the green sending wire to front. It might be pinched on body/frame over by the left rear wheel. I pulled the drivers seat and under the carpet are two wire bundles with connections. I disconnected the gas gauge harness under the seat. Test from fuel tank showing 0 ohms. Tested towards the gauge with potentiometer. Fuel gauge showed E when disconnected. With 0 ohms applied the gauge goes to F, it goes down to 1/2 at 45 and just above E on 90. The fuel tank was drained. I’ll see if I can clear the green wire from the pinch and drop tank to see if it’s getting grounded out on the pinch or somewhere else. To be continued!
|
| All times are GMT -7. The time now is 07:07 AM. |
|
Powered by vBulletin® Version 3.8.0
Copyright ©2000 - 2024, Jelsoft Enterprises Ltd.
Search Engine Friendly URLs by vBSEO 3.6.0
The representations expressed are the representations and opinions of the clubcobra.com forum members and do not necessarily reflect the opinions and viewpoints of the site owners, moderators, Shelby American, any other replica manufacturer, Ford Motor Company. This website has been planned and developed by clubcobra.com and its forum members and should not be construed as being endorsed by Ford Motor Company, or Shelby American or any other manufacturer unless expressly noted by that entity. "Cobra" and the Cobra logo are registered trademarks for Ford Motor Co., Inc. clubcobra.com forum members agree not to post any copyrighted material unless the copyrighted material is owned by you. Although we do not and cannot review the messages posted and are not responsible for the content of any of these messages, we reserve the right to delete any message for any reason whatsoever. You remain solely responsible for the content of your messages, and you agree to indemnify and hold us harmless with respect to any claim based upon transmission of your message(s). Thank you for visiting clubcobra.com. For full policy documentation refer to the following link:
