Club Cobra Keith Craft Motorsports  

Go Back   Club Cobra > Manufacturers, Engine Builders, tools, and parts. > ERA---Speak with Bob Putnam

MMG Superformance
Nevada Classics
Main Menu
Module Jump:
Nevada Classics
Nevada Classics
MMG Superformance
MMG Superformance
Advertise at CC
Banner Ad Rates
MMG Superformance
Keith Craft Racing
March 2024
S M T W T F S
          1 2
3 4 5 6 7 8 9
10 11 12 13 14 15 16
17 18 19 20 21 22 23
24 25 26 27 28 29 30
31            
  #1 (permalink)  
Old 03-26-2007, 07:10 PM
birddog's Avatar
CC Member
Visit my Photo Gallery

 
Join Date: Dec 2006
Location: Charlestown, RI
Cobra Make, Engine: ERA 289 FIA #2009, Boss 302
Posts: 29
Not Ranked     
Default Dead battery caused by voltage regulator?

Can a bad voltage regulator (stuck contacts) kill an otherwise good battery? The battery (MT-62) in my ERA has been fine until Sunday. Completely Dead. I confirmed nothing was left on. While charging the battery I decided to remove it and when I unplugged the charger I heard a clicking under the hood. After repeatably plugging/unplugging the charger I determine the source of the clicking was the voltage regulator which was a little warm to the touch. Pretty suspicious since I never had the car running. I plan to replace both the battery (unknown age) and the voltage regulator but wonder if I should be checking something else.
Reply With Quote
  #2 (permalink)  
Old 03-27-2007, 03:52 AM
CC Member
Visit my Photo Gallery

 
Join Date: Nov 2003
Location: New Britain, CT
Cobra Make, Engine: Size 10 Feet
Posts: 2,993
Not Ranked     
Default

The field terminal of the VR normally gets its power only when the ignition is on. You may be getting feedback from a defective alternator or wiring problems between the regulator and the alternator.

With the ignition off and a live battery connected, disconnect the voltage regulator plug. If you hear the clicking, then the problem is as described above. You will probably have to replace the regulator with the alternator.
Reply With Quote
  #3 (permalink)  
Old 03-27-2007, 04:19 AM
Senior Club Cobra Member
Visit my Photo Gallery

 
Join Date: Jun 2005
Location: DeLand, FL, fl
Cobra Make, Engine: ERA FIA #2117; 331 stroker; TKO600
Posts: 588
Not Ranked     
Default

Birddog. I believe you most likely need to replace your battery. It is the original one and that car was built in 2000. I test drove the car in June of 2006 (I was in the neighborhood visiting my mom), and the dealer in New York said the battery was dead the week before I got there and they had to come up with a way of charging the battery without removing the rear wheel to gain access to the FIA battery compartment. They figured it out. Real nice car, get a new Optima dry cell. Have fun. Rick
Reply With Quote
  #4 (permalink)  
Old 03-27-2007, 05:11 PM
birddog's Avatar
CC Member
Visit my Photo Gallery

 
Join Date: Dec 2006
Location: Charlestown, RI
Cobra Make, Engine: ERA 289 FIA #2009, Boss 302
Posts: 29
Not Ranked     
Default

Thx Bob / Rickd. I replaced the battery and the VR and everything is fixed. The VR had a cooked relay. I replaced w/ a solid state and swapped the Ford black cover from original by drilling the rivets on the replacement VR. Car starts on first try now ..after learning proper method from other thread. I also pulled all of the wheels and applied anti-seize, adjusted the Spax and raised the rear by an inch. I also installed the tonneau studs in preparation for a cover. Just waiting on wind wings and sun visors. I probably will install a carpet as well. Coming together. Thanks for the help. Jeff
Reply With Quote
  #5 (permalink)  
Old 03-27-2007, 05:24 PM
birddog's Avatar
CC Member
Visit my Photo Gallery

 
Join Date: Dec 2006
Location: Charlestown, RI
Cobra Make, Engine: ERA 289 FIA #2009, Boss 302
Posts: 29
Not Ranked     
Default

Bob, I replaced the VR before I read your reply but I did test the new one as described and passed the test. Hopefully this means the alternator is OK. I tested the charging voltage and everything looked fine. thx jeff
Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On



All times are GMT -7. The time now is 11:51 AM.


Powered by vBulletin® Version 3.8.0
Copyright ©2000 - 2024, Jelsoft Enterprises Ltd.
Search Engine Friendly URLs by vBSEO 3.6.0
The representations expressed are the representations and opinions of the clubcobra.com forum members and do not necessarily reflect the opinions and viewpoints of the site owners, moderators, Shelby American, any other replica manufacturer, Ford Motor Company. This website has been planned and developed by clubcobra.com and its forum members and should not be construed as being endorsed by Ford Motor Company, or Shelby American or any other manufacturer unless expressly noted by that entity. "Cobra" and the Cobra logo are registered trademarks for Ford Motor Co., Inc. clubcobra.com forum members agree not to post any copyrighted material unless the copyrighted material is owned by you. Although we do not and cannot review the messages posted and are not responsible for the content of any of these messages, we reserve the right to delete any message for any reason whatsoever. You remain solely responsible for the content of your messages, and you agree to indemnify and hold us harmless with respect to any claim based upon transmission of your message(s). Thank you for visiting clubcobra.com. For full policy documentation refer to the following link: CC Policy
Links monetized by VigLink