|
Somethings not right!
Last October I installed a new 180 F thermostat and it worked great. My cooling water ran about 75 C (167 F). I just went for a ride and noticed the water temp never got over about 50 F (122 F). When I got home I let it idle until the cooling water got up to about 93 C (200 F) when the fans kicked on. Of course I don't want to drive around with "cold" cooling water, so I'm wondering if there is anything else that could cause this besides a stuck open thermostat. I find it hard to believe the Thermostat has failed already.
|
Your thermostat is stuck open.
Thermostat controls minimum temp, radiator and airflow controls max temp, within reason. |
That or you have an air pocket in the system.
|
Quote:
|
Quote:
|
Did you drill holes in the thermostat prior to installation?
If not, your thermostat is stuck open, or it is opening way before it is supposed to. And, yes, they can be defective right out of the box. Replace it and your problems will disappear. |
you need to bleed that air out of the system!
|
Take out the thermostat, put in a pot of water on the stove and let it cycle 3 or 4 times, betting it's sticking open, if so, throw it away and get a new, test the new one on the stove before installing, I've had a new one stick open on it's first cycle out of the box........
David |
I topped off the coolant with the engine cold. I warmed up the engine in the driveway after shutting down the engine, I heard it gurgle a little (Maybe to the overflow reservoir). It warmed up fine and the fans kicked on at about 92C (198 F) and it dropped to about 80C (176F). On the freeway, the water temp cooled to about 50C (122 F). Pulled over let the water temp warm up to 80C and back on the freeway where it cooled to about 50C again. The oil temp was around 70 C. The weather here is cool at 55 F. After all that, I can't believe it, but I must have a stuck thermostat! I don't think I have an air pocket and I didn't drill or have any holes in the thermostat. It still doesn't seem possible! I'll get a new thermostat tomorrow! RATS! Thanks for the ideas and suggestions.
|
WardL, my car does the same thing, you have to remember that a SPF has a excellent cooling system. When the air temp is cooler, I have to block off half my radiator to keep the heat up on the freeway.
|
Ward, what was the problem with the thermostat last oct. SPF # 2773 Jerry
|
Quote:
Ward, the main purpose of the little holes in the thermostat is to purge the air when filling your cooling system to help eleminate air pockets....... David |
Next time when filling the radiator loosen the temp sending unit on the manifold and let the air bleed out, when you see coolant tighten it up, you will have no air.
|
Quote:
|
Your thermostat is stuck, Go to your Ford dealer and get a 192° Motorcraft thermostat. Your engine will thank you. Modern engines with aluminum heads need more heat for best thermal efficiency. Old habits have us overcooling our engines. You'll be surprised how much better your engine will run. Some time back I tested several brands of thermostats and the Motorcraft were the only ones that opened at the stated temp.
Frank |
Plenty of good words of wisdom here, thanks! The Motorad Fail-Safe 180 F thermostat had failed open. The parts store only had a 192 F and Like Frank, I was thinking it would be OK. After getting back home I remembered the Roush book saying 180 F. After looking online, it seems the fail-safe thermostats have a tendency to fail regularly. One guy said he was on his 5th fail-safe thermostat and was happy with them! Maybe anytime the temps get 20 F above the set point they fail open. I don't want to be changing my thermostat every time it gets hot. I am going to get a 180 F Motorcraft and forget about it. I'll have to dig pretty deep as they cost $15, but maybe that is why they work well. LOL....
I replaced the thermostat last year because it was set up with a thermostat that is designed to be partially open at a minimum and with NO bypass hose around the thermostat. I had purchased my Cobra from a very hot climate (Florida) and it was set for max cooling all the time. Roush advises to always use a thermostat bypass. I set it up with a bypass hose and a fail-safe thermostat. Again, thanks for the good info! |
Quote:
|
Bingo2: Apparently you can't find a Motorcraft 180 F thermostat in Washington State! Ford said they could order one from Oregon. I couldn't find a "normal" 180 thermostat today. Tomorrow I hope to buy a 190 F Motorcraft thermostat at Ford. I'd be curious if you found a Motorcraft 180 F today. I need it this weekend so I'll go with the hotter one as suggested by Frank. I've been saying I need a thermostat for a 1995 F-150 5.8L 351 Windsor engine. Does that engine have a 180 F thermostat?
|
Ward...perhaps not in CA either. The dealer had 192 and 197 and the parts guy said he wasn't certain there is a 180 available.
|
Quote:
I know the later model GT Mustangs had 192 thermos in them..... David |
| All times are GMT -7. The time now is 03:08 AM. |
Powered by vBulletin® Version 3.8.0
Copyright ©2000 - 2025, Jelsoft Enterprises Ltd.
Search Engine Friendly URLs by vBSEO 3.6.0
The representations expressed are the representations and opinions of the clubcobra.com forum members and do not necessarily reflect the opinions and viewpoints of the site owners, moderators, Shelby American, any other replica manufacturer, Ford Motor Company. This website has been planned and developed by clubcobra.com and its forum members and should not be construed as being endorsed by Ford Motor Company, or Shelby American or any other manufacturer unless expressly noted by that entity. "Cobra" and the Cobra logo are registered trademarks for Ford Motor Co., Inc. clubcobra.com forum members agree not to post any copyrighted material unless the copyrighted material is owned by you. Although we do not and cannot review the messages posted and are not responsible for the content of any of these messages, we reserve the right to delete any message for any reason whatsoever. You remain solely responsible for the content of your messages, and you agree to indemnify and hold us harmless with respect to any claim based upon transmission of your message(s). Thank you for visiting clubcobra.com. For full policy documentation refer to the following link: